Tycon Power MPPT Solar Switch Charge Controller PoE Switch

0 Rating
$1,019.00 +GST
Login for your price
17 In Stock
1 - 4$1 019.00
5 - 9$993.53
10 - 19$968.05
Tycon Power MPPT Solar Charge Controller with Integrated Remote Power Monitor and 7 Port Passive Gigabit PoE Switch
Package Contents
The Tycon Power TPDIN-SC48-20 V2+ is a web manageable MPPT Solar Controller with built-in 7 Port Gigabit Passive PoE switch. The controller uses temperature compensated smart battery charging to properly charge GEL or AGM or Lithium batteries and extend their life. It has a balance charge mode for periodic battery bank maintenance. There are 4 Gigabit 802.3at or 24/48V Passive PoE and 3 Gigabit 24/48V Passive PoE ports. Each port is capable of 0.645A Max. There is a wire terminal auxiliary output capable of 2.25A maximum. Total from all outputs is set at 150W at 48VDC and 72W at 24VDC for a max total of 222W. Outputs can be switched by user between 802.3at (port 1-4 only), 48VDC, 24VDC or OFF through the web interface.

The web interface has full capabilities to measure and log battery voltage, battery current, input voltage/current, load current and battery temperature. Ports can be controlled by a settable ping watchdog to power cycle the port if communications to the unit are interrupted. Auxiliary port can be controlled by voltage or temperature or time so it can be programmed to control lights, pumps, generators, heaters, fans, etc. The unit supports automated Email alerts if user programmed limits are exceeded so that the user can be alerted in case of developing problems at the site.

The controller can also be powered through an external AC to DC power supply connected to the PV+/PV- input in order to charge the batteries from an AC source like grid power or generator.

All inputs and outputs are surge and overload protected. Connectors and battery fuse are removable for easy maintenance. The controller can be mounted using the integral DIN rail mount bracket or using 2 mounting tabs.
  • TPDIN® MPPT 48V 20A Solar Controller
  • Temperature Compensated Smart Battery Charging
  • 7 Port Gigabit PoE Switch
  • Remote Monitor and Control
  • 48V or 24V User Selectable Output Voltage
  • 2.25A Auxiliary Wire Terminal Output
  • Total 200W Power Output
  • Automatic Low Voltage Battery Disconnect
  • DIN Rail or Screw Tab Mounting
Manufacturer's Product CodeTPDIN-SC48-20 V2+
Solar Input Voltage56VDC Min to 100VDC Max
Max Solar Panel Open Circuit Voltage (Voc)100VDC (Maximum worst case over full temperature range)
Max Solar Panel Power Point Voltage (Vmp)90VDC
Solar Input Current20A Maximum
Typical Controller Efficiency96% (68VDC Input, 10A Load, 25C)
MPPT Tracking Frequency19 times/sec or 19 Hz
Battery Voltage48VDC (Controller will function down to 20VDC)
Battery Current20A Maximum
Battery TypeGEL or AGM or WET or Lithium
Temperature Compensation-3mV/°C/2V
Fuse Type58V 20A Automotive Mini Blade Type (Littlefuse 0997020.WXN)
Low Voltage Disconnect42 to 47.8 – settable in web interface
Low Voltage Disconnect Recovery44.6V to 49.2V – settable in web interface
Auxiliary DC Output Voltage24VDC or 48VDC – settable in web interface
Auxiliary DC Output Current2.25A Maximum Continuous, 3A Max peak
Auxiliary DC Output ControlsTemperature, Voltage, Time – settable in web interface
PoE SwitchQty 7 RJ45, 10/100/1000MB Gigabit Ethernet, Layer 2, Auto Crossover
PoE Output Voltage802.3at (port 1-4 only), 48VDC or 24VDC or OFF – settable in web interface
PoE Output Power0.645A per PoE Port Max, PoE Power supplied on pins 4,5 (V+) and 7,8 (V-) (Mode B)
Port Surge ProtectionIEC 61000-4-2 (ESD) 15kV (air), 15kV (contact), IEC 61000-4-4 (EFT) 40A (5/50ns), IEC 61000-4-5 (Lightning) 25A (8/20µs)
Maximum Power Output222W Total (150W @ 48VDC and 72W @ 24VDC) from all output ports (including Aux Output), Auto Shutdown and Autorecovery from Fail
Indicator LED’sCharge (Green), 24VDC (Green) or 48VDC (Yellow) Port Voltage, Overload (Red)
Measurement Accuracy (V / I / T)+/- 0.1V , +/- 0.1A , +/- 1 Deg C
Power Consumption3.5W Typ
AccessibilityVia Web Browser and SNMP
Data-LoggerFIFO, 15,000 data sets, Programmable log interval
Wire SizeSolar and Battery – 8AWG, Aux DC Output -12AWG
MountingDIN Rail or 4mm Screw Tab
Operating Temperature-40C to +65C (-40F to 149F)
Humidity (RH)0% - 90%
Dimensions (LxWxDepth)151mm x 111mm x 138mm (5.9 x 4.4 x 5.4”)
Weight1.5kg (3.3lbs)
MTBF>100,000 Hrs
CertificationsFCC/CE EN55022 (EMC) ; CE EN55024 (EMC); CE/UL EN60950-1 (LVD)
PoE (non standard) , PoE (802.3af/at)

There are yet no reviews for this product.

Please log in to write a review. Log in